Compare the2024 Ford Bronco SportVS 2024 Volvo XC40

Both the Bronco Sport and the XC40 have standard driver and passenger frontal airbags, front side-impact airbags, driver knee airbags, side-impact head airbags, front and rear seatbelt pretensioners, height adjustable front shoulder belts, four-wheel antilock brakes, all wheel drive, traction control, electronic stability systems to prevent skidding, crash mitigating brakes, post-collision automatic braking systems, daytime running lights, lane departure warning systems, blind spot warning systems, rearview cameras, rear cross-path warning, driver alert monitors and available rear parking sensors.

The National Highway Traffic Safety Administration does 35 MPH front crash tests on new vehicles. In this test, results indicate that the Ford Bronco Sport is safer than the Volvo XC40:

New test not comparable to pre-2011 test results. More stars = Better. Lower test results = Better.

The National Highway Traffic Safety Administration does side impact tests on new vehicles. In this test, which crashes the vehicle into a flat barrier at 38.5 MPH and into a post at 20 MPH, results indicate that the Ford Bronco Sport is safer than the Volvo XC40:

New test not comparable to pre-2011 test results. More stars = Better. Lower test results = Better.

For its top level performance in IIHS driver and passenger-side small overlap frontal, moderate overlap frontal, side impact, roof strength and head restraint tests, its standard vehicle-to-vehicle front crash prevention system, its standard vehicle-to-pedestrian front crash prevention system, and its standard headlight’s “Good” rating, the Insurance Institute for Highway Safety grants the Bronco Sport its highest rating: “Top Safety Pick Plus” for 2022, a rating granted to only 126 vehicles tested by the IIHS. The XC40 has not been fully tested, yet.

Ford’s powertrain warranty covers the Bronco Sport 1 year and 10,000 miles longer than Volvo covers the XC40. Any repair needed on the engine, transmission, axles, joints or driveshafts is fully covered for 5 years or 60,000 miles. Coverage on the XC40 ends after only 4 years or 50,000 miles.

There are almost 11 times as many Ford dealers as there are Volvo dealers, which makes it much easier should you ever need service under the Bronco Sport’s warranty.

The Bronco Sport has a standard “limp home system” to keep drivers from being stranded if most or all of the engine’s coolant is lost. The engine will run on only half of its cylinders at a time, reduce its power and light a warning lamp on the dashboard so the driver can get to a service station for repairs. The XC40 doesn’t offer a lost coolant limp home mode, so a coolant leak could strand you or seriously damage the truck’s engine.

J.D. Power and Associates rated the Bronco Sport third among small suvs in their 2023 Initial Quality Study. The XC40 isn’t in the top three in its category.

J.D. Power and Associates’ 2023 Initial Quality Study of new car owners surveyed provide the statistics that show that Ford vehicles are better in initial quality than Volvo vehicles. With 49 fewer problems per 100 vehicles, JD Power ranks Ford higher than Volvo.

J.D. Power and Associates’ 2022 survey of the owners of three-year-old vehicles provides the long-term dependability statistics that show that Ford vehicles are more reliable than Volvo vehicles. J.D. Power ranks Ford above average in long-term dependability. With 4 more problems per 100 vehicles in the first three years of ownership, Volvo is rated below average.

The Bronco Sport Badlands’ standard 2.0 turbo 4-cylinder produces 3 more horsepower (250 vs. 247) and 19 lbs.-ft. more torque (277 vs. 258) than the XC40’s 2.0 turbo 4-cylinder hybrid.

As tested in Car and Driver the Bronco Sport Badlands 2.0 turbo 4-cylinder is faster than the Volvo XC40:

To lower fuel costs and make buying fuel easier, the Ford Bronco Sport uses regular unleaded gasoline (premium recommended on Bronco Sport Badlands for maximum performance). The XC40 requires premium, which can cost on average about 82.8 cents more per gallon.

The Bronco Sport has 1.8 gallons more fuel capacity than the XC40 (16 vs. 14.2 gallons), for longer range between fill-ups.

In its Green Vehicle Guide, the U.S. Environmental Protection Agency (EPA) rates the Ford Bronco Sport higher (6 to 7 out of 10) than the Volvo XC40 (5). This means the Bronco Sport produces up to 8 pounds less smog-producing pollutants than the XC40 every 15,000 miles.

The Bronco Sport stops much shorter than the XC40:

The Bronco Sport offers an optional full size spare tire so a flat doesn’t interrupt your trip. A full size spare isn’t available on the XC40; it requires you to depend on a temporary spare, which limits mileage and speed before replacement.

The Bronco Sport has standard front and rear gas-charged shocks for better control over choppy roads. The XC40’s suspension doesn’t offer gas-charged shocks.

For greater off-road capability the Bronco Sport has a greater minimum ground clearance than the XC40 (8.8 vs. 8.1 inches), allowing the Bronco Sport to travel over rougher terrain without being stopped or damaged.

The Ford Bronco Sport may be more efficient, handle and accelerate better because it weighs about 250 to 400 pounds less than the Volvo XC40.

The front grille of the Bronco Sport uses electronically controlled shutters to close off airflow and reduce drag when less engine cooling is needed. This helps improve highway fuel economy. The XC40 doesn’t offer active grille shutters.

The Bronco Sport has 7.7 cubic feet more passenger volume than the XC40 (105.7 vs. 98).

The Bronco Sport has 2.5 inches more front headroom, 1.5 inches more front legroom, .5 inches more front hip room, .6 inches more front shoulder room, 2.6 inches more rear headroom and .8 inches more rear legroom than the XC40.

The Bronco Sport has a much larger cargo volume with its rear seat up than the XC40 with its rear seat up (32.5 vs. 20.4 cubic feet). The Bronco Sport has a much larger cargo volume with its rear seat folded than the XC40 with its rear seat folded (65.2 vs. 57.5 cubic feet).

The Bronco Sport’s rear cargo window opens separately from the rest of the liftgate door to allow quicker loading of small packages. The XC40’s rear cargo window doesn’t open.

In case you lock your keys in your vehicle, or don’t have them with you, you can let yourself in using the Bronco Sport’s available exterior PIN entry system. The XC40 doesn’t offer an exterior PIN entry system, and its Volvo On Call can’t unlock the doors if the vehicle doesn’t have cell phone reception or the driver can’t contact the service.

To shield the driver and front passenger’s vision over a larger portion of the windshield and side windows, the Bronco Sport has standard extendable sun visors. The XC40 doesn’t offer extendable visors.

The Bronco Sport Outer Banks/Badlands has a 115-volt a/c outlet on the center console, allowing you to recharge a laptop or run small household appliances without special adapters that can break or get misplaced. The XC40 doesn’t offer a house-current electrical outlet.

J.D. Power and Associates rated the Bronco Sport second among small suvs in owner reported satisfaction. This includes how well the vehicle performs and satisfies its owner’s expectations. The XC40 isn’t in the top three in its category.

The Ford Bronco Sport outsold the Volvo XC40 by over five to one during 2022.