Compare the2023 Ford EscapeVS 2023 Volvo XC40

Both the Escape and the XC40 have standard driver and passenger frontal airbags, front side-impact airbags, driver knee airbags, side-impact head airbags, front and rear seatbelt pretensioners, front wheel drive, height adjustable front shoulder belts, four-wheel antilock brakes, traction control, electronic stability systems to prevent skidding, crash mitigating brakes, post-collision automatic braking systems, daytime running lights, lane departure warning systems, blind spot warning systems, rearview cameras, rear cross-path warning, driver alert monitors, available all wheel drive and around view monitors.

The National Highway Traffic Safety Administration does 35 MPH front crash tests on new vehicles. In this test, results indicate that the Ford Escape is safer than the Volvo XC40:

New test not comparable to pre-2011 test results. More stars = Better. Lower test results = Better.

The National Highway Traffic Safety Administration does side impact tests on new vehicles. In this test, which crashes the vehicle into a flat barrier at 38.5 MPH and into a post at 20 MPH, results indicate that the Ford Escape is safer than the Volvo XC40:

New test not comparable to pre-2011 test results. More stars = Better. Lower test results = Better.

For its top level performance in IIHS driver and passenger-side small overlap frontal, moderate overlap frontal, side impact, roof strength and head restraint tests, its standard vehicle-to-vehicle front crash prevention system, its standard vehicle-to-pedestrian front crash prevention system, and its available headlight’s “Acceptable” rating, the Insurance Institute for Highway Safety grants the Escape the rating of “Top Safety Pick” for 2022, a rating granted to only 177 vehicles tested by the IIHS. The XC40 has not been fully tested, yet.

Ford’s powertrain warranty covers the Escape 1 year and 10,000 miles longer than Volvo covers the XC40. Any repair needed on the engine, transmission, axles, joints or driveshafts is fully covered for 5 years or 60,000 miles. Coverage on the XC40 ends after only 4 years or 50,000 miles.

There are almost 11 times as many Ford dealers as there are Volvo dealers, which makes it much easier should you ever need service under the Escape’s warranty.

The Escape has a standard “limp home system” to keep drivers from being stranded if most or all of the engine’s coolant is lost. The engine will run on only half of its cylinders at a time, reduce its power and light a warning lamp on the dashboard so the driver can get to a service station for repairs. The XC40 doesn’t offer a lost coolant limp home mode, so a coolant leak could strand you or seriously damage the truck’s engine.

J.D. Power and Associates’ 2022 Initial Quality Study of new car owners surveyed provide the statistics that show that Ford vehicles are better in initial quality than Volvo vehicles. J.D. Power ranks Ford above average in initial quality. With 89 more problems per 100 vehicles, Volvo is rated below average.

J.D. Power and Associates’ 2022 survey of the owners of three-year-old vehicles provides the long-term dependability statistics that show that Ford vehicles are more reliable than Volvo vehicles. J.D. Power ranks Ford above average in long-term dependability. With 4 more problems per 100 vehicles in the first three years of ownership, Volvo is rated below average.

The Escape’s optional 2.0 turbo 4-cylinder produces 3 more horsepower (250 vs. 247) and 22 lbs.-ft. more torque (280 vs. 258) than the XC40 B5’s standard 2.0 turbo 4-cylinder hybrid.

On the EPA test cycle the Escape gets better mileage than the XC40:

An engine control system that can shut down some of the engine’s cylinders helps improve the Escape 1.5 Turbo’s fuel efficiency. The XC40 doesn’t offer a system that can shut down part of the engine.

To lower fuel costs and make buying fuel easier, the Ford Escape uses regular unleaded gasoline (premium recommended with the 2.0 turbo 4-cylinder engine for maximum performance). The XC40 requires premium, which can cost on average about 82.8 cents more per gallon.

The Escape AWD’s standard fuel tank has 1.5 gallons more fuel capacity than the XC40 (15.7 vs. 14.2 gallons).

In its Green Vehicle Guide, the U.S. Environmental Protection Agency (EPA) rates the Ford Escape higher (7 out of 10) than the Volvo XC40 (5). This means the Escape produces up to 8 pounds less smog-producing pollutants than the XC40 every 15,000 miles.

For better stopping power the Escape’s standard brake rotors are larger than those on the XC40:

The Escape stops much shorter than the XC40:

The Escape has standard front and rear gas-charged shocks for better control over choppy roads. The XC40’s suspension doesn’t offer gas-charged shocks.

The Escape AWD handles at .87 G’s, while the XC40 B5 Ultimate AWD pulls only .85 G’s of cornering force in a Car and Driver skidpad test.

The Escape AWD executes Motor Trend’s “Figure Eight” maneuver quicker than the XC40 B5 Plus AWD (27.7 seconds @ .64 average G’s vs. 28.1 seconds @ .61 average G’s).

The Ford Escape may be more efficient, handle and accelerate better because it weighs about 400 to 450 pounds less than the Volvo XC40.

The front grille of the Escape uses electronically controlled shutters to close off airflow and reduce drag when less engine cooling is needed. This helps improve highway fuel economy. The XC40 doesn’t offer active grille shutters.

The Escape has 6 cubic feet more passenger volume than the XC40 (104 vs. 98).

The Escape has 1 inch more front headroom, 1.5 inches more front legroom, .5 inches more front hip room, .9 inches more front shoulder room, .2 inches more rear headroom and 4.6 inches more rear legroom than the XC40.

The Escape has a much larger cargo volume with its rear seat up than the XC40 with its rear seat up (37.5 vs. 20.4 cubic feet). The Escape has a much larger cargo volume with its rear seat folded than the XC40 with its rear seat folded (65.4 vs. 57.5 cubic feet).

A low lift-over cargo hatch design makes loading and unloading the Escape easier. The Escape’s cargo hatch lift-over height is 28.1 inches, while the XC40’s liftover is 29.6 inches.

The Escape’s cargo area is larger than the XC40’s in every dimension:

A Trailer Sway Control is standard on the Escape, using the AdvanceTrac® sensors to detect trailer sway, then uses individual brakes to counteract any swaying and help keep the tow vehicle and trailer steady. A trailer sway program costs extra on the XC40.

The Escape (except Base)’s optional easy entry system glides the driver’s seat back when the door is unlocked or the ignition is switched off, making it easier for the driver to get in and out. The XC40 doesn’t offer an easy entry system.

The Escape Elite/Platinum offers an optional heads-up display that projects speed and navigation instruction readouts in front of the driver’s line of sight, allowing drivers to view information without diverting their eyes from the road. The XC40 doesn’t offer a heads-up display.

In case you lock your keys in your vehicle, or don’t have them with you, you can let yourself in using the Escape’s available exterior PIN entry system (not available on Escape Base). The XC40 doesn’t offer an exterior PIN entry system, and its Volvo On Call can’t unlock the doors if the vehicle doesn’t have cell phone reception or the driver can’t contact the service.

To shield the driver and front passenger’s vision over a larger portion of the windshield and side windows, the Escape Active/ST-Line/Platinum has standard extendable sun visors. The XC40 doesn’t offer extendable visors.

The Escape Elite/Platinum’s optional Active Park Assist 2.0 can parallel park or back into a parking spot by itself, starting, stopping and changing direction automatically. The XC40’s automatic parking system requires operating the brakes and transmission to safely park.

The Ford Escape outsold the Volvo XC40 by over seven to one during 2022.